Product ID:525-0614, PAINT SPRAY, 4.5 OZ AEROSOL CAN
MSDS Date:05/06/1997
FSC:2805
NIIN:01-337-1179
Status Code:A
Kit Part:Y
MSDS Number: CLDWF

RAABE CORPORATION THE PRECISION COLOR COMPANY

N92 W14701 ANTHONY AVE.
MENOMONEE FALLS, WI 53051-1630
US

Emergency Phone: 414-255-9500

Info Phone: 414-255-9500/800-966-7580

Cage: 0A3L4

RAABE CORPORATION THE PRECISION COLOR COMPANY

1090 MENOMONEE FALLS, WI 53051-1630 US

Telephone: 414-255-9500/800-966-7580

Cage: 0A3L4

N-BUTANE

CAS: 106-97-8

RTECS: EJ4200000

OSHA PEL 800 PPM

ACGIH TLV: 1900 MG/M3;800 PPM

PROPANE

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1800 MG/M3;1000 PPM

ACGIH TLV: 1000 PPM

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 10 MG/M3

ACGIH TLV: 10 MG/M3

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 750 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

N-BUTYL ACETATE

CAS: 123-86-4

RTECS: AF7350000

OSHA PEL 710 MG/M3;150 PPM

ACGIH TLV: 713 MG/M3;150 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PROPYLENE GLYCOL METHYL ETHER ACETATE

CAS: 108-65-6

RTECS: AI8925000

Health Hazards Acute and Chronic:EYES: MAY CAUSE IRRITATION. SKIN: MAY
CAUSE IRRITATION. INHALATION: EXTREMELY HIGH CONCENTRATIONS MAY
CAUSE DROWSINESS, STAGGERING, CONFUSION, UNCONSCIOUSNESS, COMA, OR
DEATH. EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND
RESPIRATORY IRRITATION. INGESTION: NO COMMENTS. CHRONIC EFFECTS:
CHRONIC EXPOSURE HAS BEEN FOUND TO CAUSE KIDNEY DAMAGE AND EYE
DAMAGE IN LAB ANIMALS. REPORTS HAVE ASSOCIATE D REPEATED AND
PROLONGED OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS
SYSTEM DAMAGE. BREATING AIR CONTAINING N-BUTYL ACETATE, MAY CAUSE
DELAYED LUNG INJURY.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO REPORTED
CARCINOGENS OR SUSPECTED CARCINOGENS.
Effects of Overexposure:EYES: IRRITATION. SKIN: IRRITATION. INHALATION:
DROWSINESS, STAGGERING, CONFUSION, UNCONSCIOUSNESS, COMA, OR DEATH.
NASAL AND RESPIRATORY IRRITATION. CHRONIC: LUNG INJURY, BRAIN AND
NERVOUS SYSTEM DAM AGE.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS.

First Aid:EYE CONTACT: FLUSH WITH PLENTY OF WATER. GET MEDICAL
ATTENTION IF IRRITATION PERSISTS. SKIN CONTACT: WASH WITH SOAP AND
WATER AND SEEK MEDICAL ATTENTION. REMOVE CONTAMINATED CLOTHING AND
LAUNDER BEFOR E REUSE. INHALATION: MOVE TO FRESH AIR. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION AND GET MEDICAL ATTENTION.
INGESTION:DECISION WHETHER TO INDUCE VOMITING OR NOT MUST BE MADE
BY A PHYSICIAN AFTER CAREFUL CONSIDERATION OF ALL MATERIALS
INGESTED.

Flash Point:=-17.7C, .1F
Lower Limits:1.3
Upper Limits:13.1
Extinguishing Media:WATER SPRAY SHOULD NOT BE USED EXCEPT TO KEEP DOWN
VAPORS OR COOL CLOSED CONTAINERS TO PREVENT BUILD-UP OF PRESSURE.
IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS TO AVOID INHALATION OF VAPORS
SHOULD BE USED.
Unusual Fire/Explosion Hazard:AEROSOL CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE SOURCES OF IGNITION. AVOID HEAT,
SPARKS, FLAMES, AND ANYTHIG THAT COULD CAUSE A FIRE. VENTILATE AREA
AND ADJACENT LOW LYING AREAS. AVOID BREATHING SOLVENT VAPORS.
REMOVE WITH INERT ABSORBANT MA TERIALS AND NON-SPARKING TOOLS.

Handling and Storage Precautions:WASH HANDS AFTER HANDLING. STORE IN A
COOL DRY AREA WITH VENTILATION SUITABLE FOR STORING THESE
INGREDIENTS. KEEP AWAY FROM HEAT, SPARKS, AND FLAME. STORE IN A
COOL PLACE AWAY FROM DIRECT SUNLIGHT OR ANY SOURCE OF IGNITION. DO
NOT STORE AT TEMPERATURES ABOVE 120 DEGREES F.CONTENTS UNDER
PRESSURE.
Other Precautions:DO NOT USE, STORE NEAR HEAT, SPARKS, OPEN FLAME. KEEP
AWAY FROM HEAT SUCH AS SUNLIGHT, HEATERS, STOVES THAT COULD CAUSE
CONTAINER TO BURST. DO NOT PUNCTURE OR INCINERATE. DO NOT CRUSH OR
PLACE IN GA RBAGE COMPACTOR. DO NOT STORE ABOVE 120F. VAPORS
HEAVIER THAN AIR, MAY TRAVEL TO DISTANT IGNITION SO URCE AND FLASH
BACK.

Respiratory Protection:IF EXPOSURE LIMITS EXCEEDED, A NIOSH/ OSHA
APPROVED SUITABLE RESPIRATOR IS RECOMMENDED.
Ventilation:SUFFICIENT VENTILATION , IN VOLUME AND PATTERN, SHOULD BE
PROVIDED TO KEEP AIR CONTAMINATION BELOW PERMISSIBLE EXPOSURE
LIMITS.
Protective Gloves:CHEMICAL RESISTANT PLASTIC OR RUBBER GLOVES
RECOMMENDED FOR PROLONGED CONTACT.
Eye Protection:CHEMICAL GOGGLES WITH SIDE SHIELDS OR FACE SHIELD
RECOMMENDED.
Other Protective Equipment:APPROPRIATE IMPERVIOUS CLOTHING IS
RECOMMENDED IF PROLONGED OR REPEATED CONTACT IS LIKELY.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING. SMOKE IN
DESIGNATED AREAS ONLY.
Supplemental Safety and Health
THIS ENTRY DESCRIBES SECOND PART (P/N 525-0614 PAINT SPRAY, SERIAL
NUMBER XXXXX) OF A FOUR PART KIT. SEE THIS SAME NSN FOR LEAD ACID
BATTERY, SERIAL NUMBER XXXXX; AND FOR LUBRICATING OIL, SERIAL NUMBE
R XXXXX; AND FOR SERIAL NUMBER CLDVW, GASOLINE ENGINE; FOR DATA ON
OTHER THREE KIT PARTS,

HCC:V3
Boiling Pt:=-.4C, 31.F
B.P. Text:31F TO 302F
Vapor Pres:108
Vapor Density:N/
Spec Gravity:0.756 (6.29 LB/GAL)
Evaporation Rate & Reference:0.39 (N-BUTYL ACETATE= 1)
Percent Volatiles by Volume:36.6

STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME. PRODUCT IS
STABLE UNDER NORMAL STORAGE CONDITIONS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION : CARBON
DIOXIDE, CARBON MONOXIDE, AND UNIDENTIFIABLE ORGANIC MATERIALS.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.

Toxicological Information:NO SPECIFIC INFORMATION IS AVAILABLE. REFER
TO HEALTH EFFECTS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO SPECIFIC ECOLOGICAL INFORMATION IS AVAILABLE FOR THIS
PRODUCT.

Transport Information:DOMESTIC GROUND SHIPMENT OF PAINT AEROSOLS AND
ALL LIQUID PAINT PRODUCTS IN CONTAINERS OF 1-QUART OR LESS:
CONSUMER COMMODITY, ORM-D. DOMESTIC AIR SHIPMENT OF PAINT AEROSOLS
AND ALL LIQUID PAINT IN C ONTAINERS OF 1 QUART OR LESS: CONSUMER
COMMODITY, CLASS 9, ID 8000, MISCELLANEOUS LABEL. INTERNATIONAL AIR
SHIPMENTS OF PAINT AEROSOLS, FLAMMABLE, N.O.S.; CLASS 2.1, UN1950,
FLAMMABLE GAS LABEL. INTER NATIONAL AIR SHIPMENT OF LIQUID PAINT IN
CONTAINERS OF 1-QUART OR LESS: PAINT, CLASS 3, UN 1263, FLAMMABLE
LIQUID LABEL. ALL SHIPMENTS OF LIQUID PAINT OF MORE THAN I QUART:
PAINT, CLASS 3, UN 1263, PA CKING GROUP I I, FLAMMA BLE LIQUID.

SARA Title III Information:THIS PRODUCT CONTAINS NONE OF THE SUBSTANCES
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE I I I
OF SARA AND 40CFR PART 372.