Product ID:5904 010X311 SOLVENT REDUCER
MSDS Date:11/30/1994
FSC:8010
NIIN:01-386-7668
Kit Part:Y
MSDS Number: CDCMD

COURTAULDS AEROSPACE (FORMERLY DESOTO AEROSPACE)

1608 4TH ST
BERKELEY, CA 94710-5000
US

Emergency Phone: 800-228-5635/818-549-7823

Info Phone: 818-549-7823/415-526-1525

Cage: 83574

PRC-DESOTO INTERNATIONAL, INC. A PPG INDUSTRIES COMPANY

1800 GLENDALE, CA 91209 US

Telephone: 818-240-2060

Cage: 83574

HEXONE, METHYL ISOBUTYL KETONE (MIBK), 4-METHYL-2-PENTANONE

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 100%

OSHA PEL 410 MG/CUM

ACGIH TLV: 205 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL & RESPIRATORY
IRRITATION, ACUTE CNS DEPRESSION, ASPHYXIATION. SKIN: IRRITATION,
DERMATITIS. EYES: IRRITATION. INGESTION: GI IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MA Y CAUSE PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS, DEFATTING, NAUSEA, VOMITING,
DIARRHEA. OVEREXPOSURE TO SOLVENTS-CONCENTRATION DIFFICULTIES,
DIMINISHED ACTUAL DEXTERITY & MEMORY LOSS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN, LUNG & EYE
CONDITIONS.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
KEEP WARM & QUIET. SKIN: WASH W/SOAP & WATER. DON'T USE SOLVENTS.
EYES: FLUSH W/WATER FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL
CASES.

Flash Point Method:SCC
Flash Point:60F
Extinguishing Media:CO2, DRY CHEMICAL/FOAM.
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. COOL
CONTAINERS W/WATER. FOG NOZZLES ARE PREFERRABLE. WEAR NIOSH/MSHA
APPROVED SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY ACCUMULATE IN INADEQUATELY
VENTILATED/CONFINED AREAS, FORM EXPLOSIVE MIXTURES W/AIR, TRAVEL
DISTANCES, FLASHBACK/FLAME TO HANDLING SITE. (SEE SUPP)

Spill Release Procedures:PROTECT FROM IGNITION SOURCES. UNVENTILATED
AREA, WEAR AIR SUPPLIED RESPIRATOR. COVER W/ABSORBENT MATERIAL &
SCOOP INTO CONTAINER. CLEAN RESIDUE W/SUITABLE SOLVENT.

Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. ISOLATE
FROM HEAT & OTHER IGNITION SOURCES. DON'T STORE >120F. DON'T CUT,
PUNCTURE/WELD ON/NEAR DRUMS.
Other Precautions:EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS.

Respiratory Protection:WHEN SPRAYING/APPLYING, USE AN ORGANIC VAPOR
CARTRIDGE/AIR-SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS BELOW TLVS/PELS.
Protective Gloves:SOLVENT RESISTANT
Eye Protection:GOGGLES/FULL-FACE SHIELD
Other Protective Equipment:PROTECTIVE CLOTHING, SAFETY SHOWER, EYE
BATH, WASHING FACILITIES.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE CONT'D: CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO
EXTREME HEAT. VAPORS ARE >AIR & MAY COLLECT IN LOW/CONFINED AREAS.

Boiling Pt:B.P. Text:214F
Vapor Density:>1
Spec Gravity:0.801
Appearance and Odor:CLEAR LIQUID W/SOLVENT ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, ELECTRICAL EQUIPMENT, SPARKS, FLAME,
TEMP >120F.
Hazardous Decomposition Products:COMBUSTION: CO2, CO.

Waste Disposal Methods:WHEN DISPOSING, ENSURE THAT IT'S PACKAGED,
STORED, TRANSPORTED & OTHERWISE MANAGED IAW/FEDERAL, STATE & LOCAL
REGULATIONS. FLAMMABLE LIQUID UN1263.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.