Product ID:SOLVENT #1(AROMATIC NAPTHA)
MSDS Date:02/21/1991
FSC:6810
NIIN:00-201-1316
MSDS Number: BHJRT

VAN WATERS AND ROGERS

2256 JUNCTION AVE
SAN JOSE, CA 95131
US

Emergency Phone: 408-435-8700

Info Phone: 408-435-8700

Cage: 0AN91

VAN WATERS AND ROGERS

SAN JOSE, CA 95131 US

Telephone: 408-435-8700/800-424-9300(CHEMTREC)

Cage: 0AN91

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 45%

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 36%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ALIPHATIC HYDROCARBON MIXTURE

Fraction By Weight: 19%

OSHA PEL 300 PPM (VM & P)

ACGIH TLV: 300 PPM (VM & P)

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

OSHA PEL 1PPM/5STEL;1910.1028

ACGIH TLV: 10 PPM; A2; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

LD50 LC50 Mixture:TLV FOR MINERAL OIL MISTS IS 5MG/M*3
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: OVEREXPOSURE MAY LEAD TO
CENTRAL NERVOUS SYSTEM DEPRESSION, LEADING TO IRRITATION, HEADACHE,
NAUSEA, DIZZINESS, FATIGUE, CONFUSION AND UNCONSCIOUSNESS.
EYE/SKIN: MAY LEAD TO IRRITATION OR BURNS ;CHRONIC:CNS,LIVER,KIDNEY
DANAGE OR NOSE BLEED OR DERMATITIS
Explanation of Carcinogenicity:NOT A CARCINOGEN.
Effects of Overexposure:OVEREXPOSURE MAY LEAD TO RESPIRATORY
IRRITATION, NAUSEA, FATIGUE, DIZZINESS, HEADACHES, UNCONSCIOUSNESS,
DERMATITIS AND EYE IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A SKIN DISORDER SHOULD
USE CAUTION WHEN HANDLING OR USING THIS PRODUCT.

First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION PERSISTS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: GET IMMEDIATE
MEDICAL ATTENTION. DO NOT INDUCE VOMITING. NOTHING BY MOUTH IF
UNCONSCIOUS.

Flash Point:=1.7C, 35.F
Lower Limits:1 CALCULATED
Upper Limits:7 CALCULATED
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. DO NOT USE DIRECT WATER STREAM.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:EXTINGUISH IGNITION SOURCES. AVOID
ACCUMULATION OF WATER. PRODUCT WILL FLOAT ON WATER AND REIGNITE.
VAPORS MAY TRAVEL A LONG DISTANCE TO IGNITION SOURCE.

Spill Release Procedures:VENTILATE AREA. USE APPROPIATE PROTECTIVE
CLOTHING AND EQUIPMENT INCLUDING EYE PROTECTION AND RESPIRATOR OR
SCBA. ABSORB IN INERT MATERIAL, AND PLACE IN APPROPIATE DISPOSAL
CONTAINER AND SEAL. FLUSH A REA WITH PLENTY OF WATER.

Handling and Storage Precautions:STORE IN A COOL, VENTILATED WORK AREA.
KEEP CONTAINERS CLOSED WHEN NOT IN USE. COMBUSTIBLE LIQUID; EMPTY
CONTAINERS CAN BE HAZARDOUS.
Other Precautions:AVOID CONTACT WITH EYES,SKIN AND CLOTHES.DO NOT
BREATHE VAPORS/MIST;WASH THOROUGHLY AFTER EACH USE .

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR. AIR-SUPPLIED
OR FILTERING TYPE WITH ORGANIC VAPOR CARTRIDGES ARE RECOMMENDED.
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED. AVOID OPEN
ELECTRICAL SOURCES NEAR PRODUCT VAPOR AREAS.
Protective Gloves:RUBBER GLOVES.
Eye Protection:USE CHEMICAL SAFETY GOGGLES & FACESHIELD
Other Protective Equipment:PROTECTIVE CLOTHING AND RUBBER APRON TO
PREVENT PROLONGED OR REPEATED CONTACT. EYE WASH STATION AND SAFETY
SHOWER.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
DO NOT CUT,GRIND,WELD OR DRILL ON OR NEAR THIS CONTAINER.

HCC:F2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=104.4C, 220.F
Vapor Pres:22
Vapor Density:3.4
Spec Gravity:0.85
Evaporation Rate & Reference:2 (BUTYL ACETATE = 1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR,COLORLESS LIQUID,AROMATIC ODOR

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC COMPOUNDS IN BLACK SMOKE.

Waste Disposal Methods:CONTACT YOUR LOCAL ENVIRONMENTAL OFFICER.
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.